VW Golf Mk7 manualsGolf Mk7 / manual

Volkswagen Golf Mk7 Owners Manual: Vehicle lifting points

Fig. 205 shows the front lifting point and Fig. 206 the rear lifting points for a lifting platform or vehicle jack on the Volkswagen Golf Mk7. The manual is explicit: the vehicle may only be lifted at these exact points — this page explains why using any other location risks damage.

Fig. 205 Lifting point at front for the lifting platform or vehicle jack

Fig. 206 Lifting points at rear for the lifting platform or vehicle jack

First read and observe the introductory information and safety warnings 

The vehicle may only be lifted at the points shown in the illustrations   and  . If the vehicle is not raised on the lifting points shown, the vehicle could be damaged  . There is also a risk of serious injury  .

Lifting platforms with fluid filled cushions (receiving platforms) may not be used for lifting the vehicle.

There are many precautions that have to be followed when lifting a vehicle on a workshop hoist or floor jack. Do not try to lift a vehicle on a lifting platform or vehicle jack unless you have the training, knowledge and experience to be able to do so safely.

Using the jack to lift the vehicle   .

WARNING

Lifting your vehicle incorrectly with a lifting platform or vehicle jack can cause accidents and serious personal injury:
  • Always read and heed the operating instructions from the lifting platform or vehicle jack manufacturer and any legal regulations before lifting the vehicle.
  • All occupants should leave the vehicle before it is lifted.
  • The vehicle should only be lifted at the points indicated in the illustrations   and  . If the vehicle is not lifted at the points shown, it could fall off the lifting platform when work is carried out, e.g. when the engine or gearbox is removed.
  • The vehicle jacking points must be placed on the centre of the vehicle lift support surfaces, with as much surface contact between the vehicle and the support surfaces as possible.
  • Never start the engine when the vehicle is raised. The vibration of the engine could cause the vehicle to fall off the lifting point.
  • If work has to be carried out underneath the lifted vehicle, secure the vehicle with suitable jack stands with a sufficient load-bearing capacity.
  • Never climb up the lifting platform.
  • Always ensure that the vehicle is not heavier than the lifting capacity of the lifting platform.

NOTICE

  • Never lift the vehicle by the engine oil sump, the gearbox or the front or rear axle.
  • To prevent damage to the underside of the vehicle when lifting, rubber pads must be used. Ensure that the lifting platform arms are able to move freely.
  • The lifting platform arms must not be allowed to come into contact with the sills or any other part of the vehicle.

    Questions & answers

    Vehicle lifting points — Volkswagen Golf Mk7

    Where are the lifting points on the Golf Mk7?
    Front: a designated jacking point on the front subframe or crossmember, shown in Fig. 205. Rear: reinforced areas on the rear subframe or floor panel, shown in Fig. 206.
    Can I use a trolley jack anywhere under the Golf Mk7?
    No. The vehicle must only be lifted at the designated points. Lifting elsewhere can crush underbody panels, bend structural members or cause the car to fall off the jack.
    What type of jack should I use for the Golf Mk7?
    The vehicle jack supplied with the car, a workshop trolley jack, or a vehicle lift — all positioned only at the correct lifting points. Axle stands must also be placed at approved support points.
    Using a mobile telephone in the vehicle without a connection to the external aerial
    First read and observe the introductory information and safety warnings Both during telephone calls and in standby mode, mobile telephones transmit and receive radio waves, which may also be ter ...

    Rodent proofing
    First read and observe the introductory information and safety warnings Rodent proofing equipment is made up of special brushes and casings and impedes entry to the engine compartment by rodents ...

    Other materials: